Component cells of the battery must be of a type proved to meet the respective testing requirements of the Manual of Tests and Criteria, part III, subsection 38.3 (IBR, see 171.7 of this subchapter). B68 Sodium must be in a molten condition when loaded and allowed to solidify before shipment. The operator of an aircraft carrying hazardous materials must do all of the following EXCEPT: A. (4) IB Codes and IP Codes. c. Completed neutron radiation detection systems containing detectors meeting the conditions of paragraph a of this special provision must be transported as follows: (1) The detectors must be contained in a strong sealed outer casing; (2) The casing must contain include sufficient absorbent or adsorbent material to absorb or adsorb the entire gas contents; (3) The completed system must be packed in strong outer packagings capable of withstanding a 1.8 meter (5.9 feet) drop test without leakage unless a system's outer casing affords equivalent protection. The toy plastic or paper caps must be in the form of sheets, strips, rolls, or individual caps; b. 198 Nitrocellulose solutions containing not more than 20% nitrocellulose may be transported as paint, perfumery products, or printing ink, as applicable, provided the nitrocellulose contains no more 12.6% nitrogen (by dry mass). B135 For Large Packagings offered for transport by vessel, flexible or fibre inner packagings shall be hermetically sealed. (7) A code containing the letter T refers to a special provision which applies only to transportation in UN or IM Specification portable tanks. Such packages must be transported on cargo aircraft only. A112 Notwithstanding the quantity limits shown in Column (9A) and (9B) for this entry, the following IBCs are authorized for transportation aboard passenger and cargo-only aircraft. 3090 or 3091, as appropriate. A82 The quantity limits in columns (9A) and (9B) do not apply to human or animal body parts, whole organs or whole bodies known to contain or suspected of containing an infectious substance. Openings for safety relief devices on multi-unit tank car tanks shall be plugged or blank flanged. The tank car specification may be marked to indicate a test pressure of 20.68 Bar (300 psig). B116 The use of non specification, sift-proof dump or hopper type vehicles, and sift-proof roll-on/roll-off bulk bins, which must be covered by a tarpaulin, metal cover, or equivalent means is authorized for the transportation of spent bleaching earth by motor vehicle. These detectors must have a minimum burst pressure of 1800 kPa as demonstrated by design type qualification testing; and. TP44 Each portable tank must be made of stainless steel, except that steel other than stainless steel may be used in accordance with the provisions of 173.24b(b) of this subchapter. (iii) Constructing the battery with terminals that are recessed or otherwise protected so that the terminals will not be subjected to damage if the package is dropped. (ii) The following is a list of the portable tank special provisions: TP1 The maximum degree of filling must not exceed the degree of filling determined by the following: tr is the maximum mean bulk temperature during transport, and tf is the temperature in degrees celsius of the liquid during filling. Outage must be at least 5 percent at 98 C (208 F). B18 Open steel hoppers or bins are authorized. In addition, the material also must be covered with an inert gas or the container must be filled with water to the tank's capacity. (6) A code containing the letter R refers to a special provision which applies only to transportation by rail. Batteries contained in devices must be securely installed. (d) Used or spent battery exception. The packaging shall be designed for a working temperature of at least 121 C (250 F). Table 1. 357 A bulk packaging that emits hydrogen sulfide in sufficient concentration that vapors evolved from the crude oil can present an inhalation hazard must be marked as specified in 172.327 of this part. will bring you to those results. e. When offered for transport in an ammonia dispenser, the receptacles shall be connected to the dispenser in such a way that the assembly is guaranteed to have the same strength as a single receptacle. Packaging must be UN standard metal drums attached with heavy duty steel strapping to a pallet; and. Symbol Meaning Which is the correct column for hazardous materials? A200 These articles must be transported as cargo and may not be carried aboard an aircraft by passengers or crewmembers in carry-on baggage, checked baggage, or on their person unless specifically authorized in 175.10. A rocket motor to be considered nonpropulsive must be capable of unrestrained burning and must not appreciably move in any direction when ignited by any means. Each portable tank constructed of metal must be fitted with a pressure-relief device consisting of a reclosing spring loaded type, a frangible disc or a fusible element. c. The equipment, and machinery or apparatus articles conforms with 173.222 of this subchapter. Metal: 11A, 11B, 11N, 21A, 21B and 21N, b. The tank must have been designed and constructed to be capable of withstanding full vacuum. 171 This entry may only be used when the material is transported in non-friable tablet form or for granular or powered mixtures that have been shown to meet the PG III criteria in 173.127. (3) A flammable gas is a gas that meets the criteria in 173.115 of this subchapter. Table 3 authorizes Large Packagings for specific proper shipping names through the use of IB Codes assigned in the 172.101 table of this subchapter. If a tank car tank is equipped with a non-reclosing pressure relief device, the rupture disc must be perforated with a 3.2 mm (0.13 inch) diameter hole. N6 Battery fluid packaged with electric storage batteries, wet or dry, must conform to the packaging provisions of 173.159 (g) or (h) of this subchapter. 6. 79 This entry may not be used for mixtures that meet the definition for oxidizing gas. B130 When transported by motor vehicle, used diatomaceous earth filter material is not subject to any other requirements of this subchapter except for the shipping paper requirements of subpart C of part 172 of this subchapter; emergency response information as required by 172.602(a)(2) through (a)(7) of this subchapter; and the marking requirements of 172.302 of this subchapter, if the following requirements are met: a. Packagings are non-DOT specification sift-proof motor vehicles or sift-proof roll-on/roll-off bulk bins, which are covered by a tarpaulin or other equivalent means. . A11 For combination packagings, when metal inner packagings are permitted, only specification cylinders constructed of metals which are compatible with the hazardous material may be used. Mixtures containing at least 98%, by mass, of phlegmatizer are not subject to the requirements of this subchapter. (2) They must be packed in strong outer packagings and the completed package must be capable of withstanding a 1.8 meter (5.9 feet) drop without leakage of gas contents from detectors. B35 Tank cars containing hydrogen cyanide may be alternatively marked Hydrocyanic acid, liquefied if otherwise conforming to marking requirements in subpart D of this part. result, it may not include the most recent changes applied to the CFR. Cargo and portable tanks must have a design pressure of at least 1,207 kPa (175 psig). TP10 A lead lining, not less than 5 mm thick, which shall be tested annually, or another suitable lining material approved by the competent authority, is required. 49 U.S.C. 55 This device must be approved in accordance with 173.56 of this subchapter by the Associate Administrator. a. Mixtures of one or more organic lead mixtures (such as tetraethyl lead, triethylmethyl lead, diethyldimethyl lead, ethyltrimethyl lead, and tetramethyl lead) with one or more halogen compounds (such as ethylene dibromide and ethylene dichloride), hydrocarbon solvents or other equally efficient stabilizers; or. 332 Magnesium nitrate hexahydrate is not subject to the requirements of this subchapter. b. Gases of Division 2.3 and gases with a subsidiary risk of 5.1 must not be used as a propellant in a chemical under pressure. Learn more about the eCFR, its status, and the editorial process. The guns are packaged in accordance with Packing Method US 1 as specified in 173.62 of this subchapter. Column 7: Special provisions. 19 For domestic transportation only, the identification number UN1075 may be used in place of the identification number specified in column (4) of the 172.101 table. 125 Lactose or glucose or similar materials may be used as a phlegmatizer provided that the substance contains not less than 90%, by mass, of phlegmatizer. For single packagings, each packaging must correspond to a design type that has passed a leakproofness test at the Packing Group II level. TP4 The maximum degree of filling for portable tanks must not exceed 90%. (i) Tests must be performed on each type and size of bottle, for each manufacturing location. 421 This entry will no longer be effective on January 2, 2023, unless we terminate it earlier or extend it beyond that date by notice of a final rule in the Federal Register. View the most recent official publication: These links go to the official, published CFR, which is updated annually. TP18 The temperature of this material must be maintained between 18 C (64.4 F) and 40 C (104 F) while in transportation. or existing codification. The Office of the Federal Register publishes documents on behalf of Federal agencies but does not have any authority over their programs. N36 Aluminum or aluminum alloy construction materials are permitted only for halogenated hydrocarbons that will not react with aluminum. Insulating materials may not promote corrosion to steel when wet. not more than 0.1 mL/hour per 30 mL inner packaging at 20 C (68 F) produced from gradual decomposition. 110 Fire extinguishers transported under UN1044 and oxygen cylinders transported for emergency use under UN1072 may include installed actuating cartridges (cartridges, power device of Division 1.4C or 1.4S), without changing the classification of Division 2.2, provided the aggregate quantity of deflagrating (propellant) explosives does not exceed 3.2 grams per cylinder. 49 CFR 172.101 Column 7 of the 172.101 Hazmat Table lists the special provisions that apply to an individual proper shipping name. Each tank car must have a reclosing pressure relief device having a start-to-discharge pressure of 15.51 Bar (225 psig). d. The proper shipping name Printing ink related material may be used for consignments of packages containing Printing ink and Printing ink related material in the same package. A212 UN 2031, Nitric acid, other than red fuming, with more than 20% and less than 65% nitric acid intended for use in sterilization devices only, may be transported on passenger aircraft irrespective of the indication of forbidden in columns (9A) of the 172.101 table provided that: a. 26 This entry does not include ammonium permanganate, the transport of which is prohibited except when approved by the Associate Administrator. The Code of Federal Regulations (CFR) is the official legal print publication containing the codification of the general and permanent rules published in the Federal Register by the departments and agencies of the Federal Government. The manufacturer must produce technical documentation of the design type, manufacture as well as the tests and their results. The shipper must ensure that all applicable requirements of 173.185 of this subchapter are met. Fertilizers meeting the criteria for this identification number are only subject to the requirements of this subchapter when offered for transportation and transported by air or vessel. Each inner packaging contains not more than 30 mL; b. 369 In the case of non-fissile or fissile-excepted uranium hexafluoride, the material must be classified under UN 2978. It may not be used to describe articles, machinery, or apparatus for which a proper shipping name exists in the 172.101 Table. 365 For manufactured instruments and articles containing mercury, see UN3506. A8 For combination packagings, if glass inner packagings (including ampoules) are used, they must be packed with cushioning material in tightly closed metal receptacles before packing in outer packagings. Dry sodium cyanide or potassium cyanide is also permitted in siftproof, water-resistant, fiberboard IBCs when transported in closed freight containers or transport vehicles. 132 This description may only be used for ammonium nitrate-based compound fertilizers. In addition, for solid materials, special provision B54 applies. A14 This material is not authorized to be transported as a limited quantity or consumer commodity in accordance with 173.306 of this subchapter when transported aboard an aircraft. Retain a copy of each notification of pilot-in-command if requested for up to 30 days Which one of the following hazardous materials is NOT excepted from the quantity limitations in 175.75? These provisions apply only to bulk packagings. 182 Equipment containing only lithium batteries must be classified as either UN 3091 or UN 3481. 350 Ammonium bromate, ammonium bromate aqueous solutions, and mixtures of a bromate with an ammonium salt are forbidden for transport. full text search results 155 Fish meal, fish scrap and krill meal may not be transported if the temperature at the time of loading either exceeds 35 C (95 F), or exceeds 5 C (41 F) above the ambient temperature, whichever is higher. The eCFR is displayed with paragraphs split and indented to follow Alcoholic beverages containing more than 24 percent but not more than 70 percent alcohol by volume must be transported as materials in Packing Group III. For Federal Register citations affecting 172.102, see the List of CFR Sections Affected, which appears in the Finding Aids section of the printed volume and at www.govinfo.gov. B30 MC 312, MC 330, MC 331 and DOT 412 cargo tanks and DOT 51 portable tanks must be made of stainless steel, except that steel other than stainless steel may be used in accordance with the provisions of 173.24b(b) of this subchapter. The cargo transport unit shall display the UN number in a manner in accordance with 172.332 of this subchapter and be placarded on two opposing sides.
Small Units To Rent In Croydon,
Cartier Juste Un Clou Ring Small Vs Regular,
Chipotle Dessert 2021,
Abbvie Stock Forecast 2030,
Articles C